Schumacher SE 3612 User Manual download pdf

Sch487

OWNER'S MANUAL

WORKING IN VICINITY OF A LEAD-ACID BATTERY IS DANGEROUS. BATTERIES

GENERATE EXPLOSIVE GASES DURING NORMAL BATTERY OPERATION. FOR THIS

REASON, IT IS OF UTMOST IMPORTANCE THAT EACH TIME BEFORE USING YOUR

CHARGER, YOU READ THIS MANUAL AND FOLLOW THE INSTRUCTIONS EXACTLY.

GENERAL BATTERY SAFETY

1. Before you use your battery charger, be sure to read all

instructions and cautions printed on:

• Battery Charger

• Battery

• Vehicle or unit using battery

2. Use battery charger on LEAD ACID type rechargeable bat-

teries only, such as used in autos, trucks, tractors, airplanes,

vans, RV's, trolling motors, etc. Charger is not intended to

supply power to low-voltage electrical system other than in

an automotive application.

WARNING: Do not use battery charger for charging dry-

cell batteries that are commonly used with home appliances.

These batteries may burst and cause injury to persons and

damage to property.

3. Use only attachments recommended or sold by manufac-

turer. Use of non-recommended attachments may result in

fire, electric shock, or injury.

4. When disconnecting the battery charger, pull by the plug

not by the cord. Pulling on the cord may cause damage to

cord or plug.

5. Locate battery power cord so it cannot be stepped on,

tripped over, or subjected to damage or stress.

6. Do not operate charger with damaged cord or plug. Have

cord replaced immediately.

7. Do not operate charger if it has received a sharp blow, been

dropped, or otherwise damaged in any way. Take it to a

qualified professional for inspection and repair.

8. Do not disassemble charger. Take it to a qualified profes-

sional when service or repair is required. Incorrect reas-

sembly may result in electric shock or fire.

9. To reduce risk of electric shock, unplug charger from outlet

before attempting any maintenance or cleaning.

10. Do not use an extension cord unless absolutely necessary.

Use of an improper extension cord could result in fire or

electric shock. If an extension cord must be used, make

sure that:

• Pins on plug of extension cord are the same number, size,

and shape as those of the plug on the charger.

• Extension cord is properly wired and in good electrical

condition.

• Wire size is large enough for AC ampere rating of charger,

as specified below:

_____________________________________________

Length of cord (feet): 25 50 100 150

AWG size of cord: 16 12 10 8

(American Wire Gauge)

_____________________________________________

11. Always charge battery in a well ventilated area.

NEVER operate in a closed-in or restricted area without

adequate ventilation because of risk of explosive gases.

WARNING: Risk of explosive gas.

12. Locate charger as far away from battery as DC charger

cables permit.

13. Do not expose charger to rain or snow.

14. NEVER charge a frozen battery. If battery fluid (electrolyte)

is frozen, bring into a warm area to thaw before charging.

15. NEVER allow battery acid to drip on charger when reading

specific gravity or filling battery.

16. NEVER set a battery on top of charger.

17. NEVER place charger directly above battery being charged.

Gases from battery will corrode and damage charger.

18. NEVER touch the battery clips together when the charger

is energized.

487-699

MODEL

SE 3612

Read Rules for

Safe Operation

and Instructions

Carefully

• IMPORTANT SAFETY INSTRUCTIONS •

• SAVE THESE INSTRUCTIONS •

ELECTRIC CORPORATION

801 BUSINESS CENTER DRIVE • MOUNT PROSPECT, ILLINOIS 60056-2179

Send Warranty Product Repairs to: P.O. Box 280 • 1025 East Thompson Avenue, Hoopeston, IL 60942

Call Customer Service if you have questions: 1-800-621-5485

1 2 3 4 5 6 7 8

Summary of Contents

Page 1 - • SAVE THESE INSTRUCTIONS •

1Sch487OWNER'S MANUALWORKING IN VICINITY OF A LEAD-ACID BATTERY IS DANGEROUS. BATTERIESGENERATE EXPLOSIVE GASES DURING NORMAL BATTERY OPERATION.

Page 2 - GROUNDING

2Sch4871. WARNING: Wear complete eye protection and clothingprotection, when working with lead-acid batteries.2. Make sure someone is within range of

Page 3

3Sch487OPERATING INSTRUCTIONS: CHARGING BATTERY IN VEHICLEWhen charging battery in the vehicle, take care to determine the battery type and which post

Page 4 - H. OUTPUT SELECTOR CONTROLS

4Sch487H. OUTPUT SELECTOR CONTROLSSwitchesSelectdown12v 40Aup12v 2A#1#2#312v 200AStart6v 40Aor6v 100AStartCHARGING STARTDC AMPS0 10203

Page 5 - K. BATTERY CHARGING

5Sch487CHARGE RATE*/CHARGING TIME - HOURS**2 AMP 10 AMP 30 AMP 40 AMP 60 AMPMotorcycle, Garden 6 - 12 AH 3-6Tractor, etc. 12 - 32 AH 3 - 18200 - 315 C

Page 6 - LOCALIZACION DE AVERIAS

6Sch487LIMITED WARRANTYSCHUMACHER ELECTRIC CORPORATION, 801 BUSINESS CENTER DRIVE, MOUNT PROSPECT, IL 60056-2179 MAKES THIS LIMITEDWARRANTY TO THE ORI

Page 7 - Calibre AWG*: 16 12 10 8

7Sch487A. SEGURIDAD GENERAL DE ACUMULADORES1. Antes de usar su cargador de acumuladores, lea todas las instruccionesy precauciones impresas en:• el ca

Page 8

8Sch4873. Conecte la pinza POSITIVA (ROJA) del cargador al terminal POSITIVO(POS, P, +) del acumulador. Gire la pinza de ida y vuelta para hacer unbue

Comments to this Manuals

No comments

Schumacher SE 3612 User Manual

Browse online or download User Manual for Accessories communication Schumacher SE 3612. Schumacher SE 3612 User Manual

Summary of Contents

Comments to this Manuals

Related products and manuals for Accessories communication Schumacher SE 3612